North America / English Change

 

Flow-Mate
130 Series

Effluent or dewatering submersible pump for septic tank, low pressure pipe (LPP) and enhanced flow STEP systems.

 
 
Features andBenefits
ProductSpecifications
TechnicalData
Literature and Documents

  • Castings - Model 137, all cast iron ASTM class 25, 2500# tensile strength. Model 139, all bronze.
  • Corrosion-resistant, powder coated epoxy finish (model 137)
  • Durable, cast iron construction - switch case motor and pump housing, base and impeller
  • Float-operated, 2-pole mechanical switch (automatic units only)
  • No sheet metal parts to rust or corrode
  • Oil-filled and hermetically-sealed, automatic reset thermal overload protected (1 Ph) motor
  • Upper and lower sleeve bearings running in bath of oil
  • Carbon and ceramic shaft seal
  • Stainless steel screws, bolts, guard, handle, arm and seal assembly
  • Maximum temperature for effluent or dewatering: 130°F (54°C) (extra duty: 140°F / 60°C)
  • Passes 5/8” (16 mm) spherical solids
  • No screens to clog
  • 1½” NPT discharge (1 ½” x 2” PVC Adapter fitting included with BN & BE Models)
  • On point: 10” (25.4 cm)
  • Off point: 2-3/4” (7 cm)
  • Simplex and duplex package systems available
  • Variable level control systems available, designed for heavy-duty effluent applications
  • Automatic and nonautomatic models available

Consult Factory for Special Applications   

  • Electrical alternators for duplex systems are available and supplied with an alarm
  • Mechanical alternators for duplex systems are available with or without alarm switches
  • Simplex panels are available for 3 Ph pumps
  • Control alarm systems are available for 1 Ph pumps
  • Variable level control switches are available for controlling 1 and 3 Ph systems
  • Double piggyback, variable level float switches are available for variable level long cycle controls
  • Over 130° F (54° C) - special quotation required
  • Consult factory for temperatures over 130° F (54° C)

Notes

Note: The sizing of effluent systems normally requires variable level float(s) controls and properly sized basins to achieve required pumping cycles or dosing timers with non-automatic pumps.

 

Pumps must be operated in upright position.

 

Reserve Powered Design.

For unusual conditions a reserve safety factor is engineered into the design of every Zoeller pump.

HERTZ
60 Hz
MOTOR
1/2 HP
VOLTAGE
115 - 460 V
PHASE
1 or 3 Ph
RPM
1750 RPM
TYPE
Split phase or 3 phase
INSULATION
Class A or B
AMPS
1.4 - 10.7 Amps
OPERATION
Automatic or nonautomatic
AUTO ON/ OFF POINTS
10" / 2-3/4" (25.4 cm / 7 cm)
DISCHARGE SIZE
1-1/2" NPT
SOLIDS HANDLING
5/8" (15 mm) spherical solids
CORD LENGTH
10' (3 m) auto, 15' (5 m) nonauto
CORD TYPE
UL listed, 3-wire neoprene cord
MAX HEAD
26' (8 m)
MAX FLOW RATE
93 GPM (352 LPM)
MAX OPERATING TEMP
130° F (54° C)
COOLING
Oil filled
MOTOR PROTECTION
Auto reset thermal overload (1 Ph)
CAP
Cast iron or bronze
MOTOR HOUSING
Cast iron or bronze
PUMP HOUSING
Cast iron or bronze
BASE
Cast iron or bronze
UPPER BEARING
Sleeve bearing or bronze
LOWER BEARING
Sleeve bearing or bronze
MECHANICAL SEALS
Carbon and ceramic
IMPELLER TYPE
Non-clogging vortex
IMPELLER
Cast iron or bronze
HARDWARE
Stainless steel
MOTOR SHAFT
AISI 1215 cold roll steel
GASKET
Neoprene
  • 54
  • 2
  • 8
  • 11
  • 13

Model Comparison Charts

Performance Curves

Dimensional Data Drawings

Caution

All installation of controls, protection devices and wiring should be done by a qualified licensed electrician. All electrical and safety codes should be followed including the most recent National Electric Code (NEC) and the Occupational Safety and Health Act (OSHA).

Selection Guide

  1. Integral float operated mechanical switch, no external control required.
  2. For automatic use single piggyback variable level float switch or double piggyback variable level float switch. Refer to FM0477.
  3. See FM1228 for correct model of simplex control panel.
  4. See FM0712 for correct model of duplex control panel.
  5. See Basins.

Optional Pump Stand P/N 10-2421

Accessories

 

×
×